Welcome to ECVERY
10KW WIND TURBINE
10KW WIND TURBINE
Supplier Info
[China Supplier]
Contact Person : Ms. Shen Maggie
Tel : 86-573-82289565
Fax : 86-0573-82289353
Product Detail
1.Wind Turbine type:WPS-10000W 2.Rated Power: 10 kWMax 3.Power: 12 kW 4.Output Voltage: 220V-300V / 360-420V

RATED POWER

10 KW

MAX POWER

12KW

OUTPUT VOLTAGE

280 V

START WIND SPEED

2 m/s

RATED WIND SPEED

10 m/s

MAX WIND SPEED

25 m/s

Cut-Out Wind Speed 

None

Blade Pitch Control

None, Fixed Pitch

Overspeed Protection

Auto Furl

Gearbox

None, Direct Drive

Temperature Range

-40 to +60 Deg. C (-40 to +140 Deg. F)

ROTOR Diameter

8m

Rotor speed

190rpm

blade

3

Blade material

Reinforced fiber glass

Height of tower

12m

Generator

3 phase permanent magnet alternator

Sine Inverter power output

AC 110/220V, 50HZ/60HZ

Packing for shipping

315x115x45cm,138x82x54cm420x98x34cm / Weight:1200kg

Functional Features

Low-End Boost, Slow-Mode

Battery Configurations

Battery Specifications: 12V/200AHMinimum Battery Quantity: 20 pieces

Blades/Rotor System

The rotor system consists of three fiberglass blades. Acting like aircraft wings, the blades convert the energy of the wind into rotation forces that can drive a generator. The rotor has three blades because three blades will run much smoother than rotors with two blades. The dogvane on the turbine can, together with the micro processor in the controller, push the rotor over to the side, away from the wind.

Alternator

The alternator converts the rotational energy of the rotor into electricity. The alternator utilized permanent magnets and produce three phase AC electric power. The internal windings and central shaft rotate, while the outside housing are stationary. The alternator was specially designed for the FD5KW and produces power at low speeds of 2m/second only., eliminating the need for a speed increasing gearbox.

The output from the alternator is three-phase alternating current(AC), but it is rectified to direct current by the charge controller. Since it uses permanent magnets, the alternator is generating voltage whenever the rotor is turning.

Nacelle

The nacelle is the steel housing around the main body of the machine. It contains the main structural backbone of the turbine(called the mainframe), the slip-ring assembly, the yaw bearings and the tower mount. The yaw bearings allow the wind turbine to freely pivot around the top of the tower so that the rotor will face into the wind.

The slip-ring assembly is the electrical connection between the moving(as it orients with the wind direction) wind turbine and the fixed tower wiring. The slip-rings and yaw bearings are located just above the tower mount. The tower mount attaches the WPS-10KW to the top of the tower.

High wind protection system

The high wind protection system, composed of a dogvane, anemometer and a micro processor which is inside the controller box. The dogvane is mounted on the nacelle(Figure 25), while the anemometer can be mounted on the building roof or anywhere high above the ground ( Figure 33 ) . During periods of high wind speeds(wind speed over 25 m/s), the anemometer detects it and send a message to the micro processor inside the controller which instruct the dogvane on the turbine and a DC motor against the turbine yawing. The rotor will turn over to the side, away from the wind , thus reducing the power output significantly. The rotor is kept facing into the wind at speeds up to 25 m/s, therefore the rotor will rotate again once the wind speed falls down 25 m/s.

Charge Controller The charge controller, shown in Figure 3 and Figure 4, has a rectifier module which rectify the three phase AC power from the turbine into DC power, proving power for batteries bank and house applications. The built-in micro processor is a important part of the high wind protection system and batteries bank protection system. Charge Controller

The charge controller, shown in Figure 3 and Figure 4, has a rectifier module which rectify the three phase AC power from the turbine into DC power, proving power for batteries bank and house applications. The built-in micro processor is a important part of the high wind protection system and batteries bank protection system.

10KW WIND TURBINE

Ads by Google

About Us | Contact Us | Help | Terms & Conditions
Hot Products: A | B | C | D | E | F | G | H | I | J | K | L | M | N | O | P | Q | R | S | T | U | V | W | X | Y | Z | 0-9
Copyright Notice @ 2008-2022 ECVERY Limited and/or its subsidiaries and licensors. All rights reserved.